阻燃耐火电力电缆生产

阻燃电线电缆一系列产品COMBUSTION-RETARDANT WIRE & CABLE SERIAL PRODUCTS一、产品标准 Product Standardare: 70℃, 90'℃' and 105'℃企标同时产品除阻燃特性执行IEC332外，其它均等效3.短路时（5S）导体高允许温度不超过：70℃为160℃：90-℃为250℃。采用该产品相应的非阻燃型产品的国家标准（GB/T)。Enterprise standard. At the same time,apart from imple-menting IEC332 for combustion retardant characteristies.prod-ucts also adopt state standard(GB/T)for non-combustion-resistingtype equivalent to the products.For short cireuit(5S),the max. work temperature of co-nductor does not exceed 160'℃for 70℃: 250℃for 90℃.4.电缆的敷设温度不低于0℃.The temperature for laying cable is not less than 0℃.如：限燃电力电缆等效采用GB/T12706-20085.电缆弯曲半径，执行相应非阻燃电缆标准的规定。Cable bend radius implements corresponding non-com-bustion. retardant cable standard stipulation.For example: Combustion-retardant power cable adoptsequivalent standand GB/T 12706-2008.阻燃控制电缆等效采用GB/T9330-20086.阻燃特性按阻燃类别可分为A.C二类（B类）。Combustion-retardant control cable adopts equivalent stan-dard GB/T 9330-2008.Combustion-retardant characteristies can be divided intocategories A and C(category B is not recommended).a.ZRC型阻燃电缆用于要求通过IEC332-3C类的一般阻燃场所。阻燃安装电线电缆等效采用GB/T5023-2008Combustion-retardant installing wire and cable adoptsequiv-alent standard GB/T 5023-2008.ZRC-type combustion. retardant cable is used in gen-eral combustion. retardant places requiríng IEC332-3C category.二、用途 Usage本产品适用于非限燃型电力电缆，电气装备用电线电缆相应产品所适用的一切使用场所，且同时要求阻燃的环境及条件。b.ZRA型阻燃电缆用于要求通过IEC332-3A类较为苛刻的阻燃场所。This product is suitable for use in all places using non-com-bustion -retardant type power cable,electrical equipment -use wireand cable and all corresponding products and at the same time re-quires combustion-retardant environment and conditions.ZRA-type combustion.retardant cable is used in com-bustion-retardant places requiring relatively harshlEC332-3A category.c.单根电缆应达到通过IEC332-1（2)不延燃的要求，即自三、使用特性Property for Use熄性，多根或成束电缆在通过IEC332-3后仅在一定范围内燃烧，并能自熄。1.额定电压（U/U），按不同产品系列分别从300/300V到26/35KVRated voltage(U/o/1),from 300/300V to 26/35KV ac-cordingto different kinds of product series.Single cable should reach the requirement of IEC332-1(2) non-buming,that is,self -extinguishing nature.Multi-cable or a bundle of cable will only burn in acertain scope after reaching the IEC332-3 stan-dandand will extinguish itself.2.电缆的高长期允许工作温度分为：70℃、90℃、105℃The max. work temperature of cable for a long period四、型号及规格 Type and Specification1.电缆型号如表1（表中列出型号均为每个品种系列的代表）For cable types,see Table I(the types in the Table are representatives of each kind.)表!Tablel型号额定电压名称Name使用范围Rated VoltageScope of ApplicationType铜芯浆氯乙烯绝缘阻燃电力电缆Copper core PVC insulated combustion-retardantpower cableZRA(C)-VV0.6/IKV铝芯聚氯乙烯绝缘阻燃电力电缆▁ZRA(C)-VLVAluminium core PVC insulted combustion-retardantpower cable核电站、地铁、通讯站、高层建筑、石油、治金、发电厂。军事设施、解道等铜芯交联聚乙烤绝缘聚乙烤护套阻燃电力电缆Copper XLPE insulated PE sheathed combustion-retardant power cable. …-ZRA(C)-YJYNuclear power station,un-derground railway.telecommunicationsstation,high rises,petroleum, metallurgy.power plant,military in-stallations,tunnel,etc.0.6/1-8.7/10KVZRAM(C)-YJLV铝芯交联聚乙烯绝缘桨氯乙绿护套铠装阻燃电力电缆Aluminium core XI.PE insulated PVC sheathed.armored combustion-retardant power eable铜芯聚氯乙烯绝缘阻燃控制电缆Copper core PVC insulated combustion-retardantcontrol cable. -ZRA(C)-KVV铜芯聚氯乙烯绝绦阻燃控制软电缆ZRA(C)-KVVR450/750VCopper core PVC insulated combustion-retardantcontrol soft cable . --_--ZRA(C)-KVVP铜芯聚氯乙烯绝缘金属屏蔽铠装阻燃控制电缆Copper core PVC insulated,metal sereened,armoredcombustion-retardant control cable

耐火电线电缆系列产品FIRE-PROOF WIRE AND CABLE SERIAL PRODUCTS一、产品标准 Product Standard（对1一a而言）。For short circuit(ös). the allowed max,work tempera-ture of conductor does not exceed 160'Cand 250'℃(for1-a).企业标准，本标准等效采用GB/T 19666-2005 Enterprisestandard, this standard is equivalent to GB/T 19666-2005.二、用途 Usage4.电缆数设时环境温度应不低于O:C.本产品适用于交流额定电压1-10KV塑料绝缘电力电缆、450Eavironmental temperature for laying cable should benot less than 0℃./750V塑料绝缘控制电缆，450/750V及以下电气装备用电线电缆所使用的任一场所，尤其是高温、易燃，要求耐火的各类输配电、控制、报警和消防系统等线路。5.电缆允许小弯曲半径按不同产品品种分别为：6倍、10倍、12倍、15倍的电缆外径This produet is suitable for use in all places using rated ACvoltage 1-10KV plastic insulated power cable, 450/ 750V plasticinsulated control cable, 450/ 750V and below electrical equipme-nt wire and cable, particularly high temperature, inflammable a-nd fire. proof for transmitting and distributing power, control,alarm and fire–control system and other circuits.Allowed min. bend radius of cable should be accordingto different kinds of the following products: 6 times. 10times, 12 times and 15 times of cable overall diameter.电缆燃烧性6.电Cable combustion naturea.在火焰温度750-800℃燃烧条件下，电境可正常运行不低于90分种。三、使用特性 Property for UseU'nder flame temperature 750-800 Ccombustionconditions, cable can normally operate not less than90 min.1.额定电压按不同产品品种可分为：According to different product kinds, rated voltage canbe divided into the following:1.在a环境下所测得电缆的载流量不低于相应型号规格的普通电缆工作条件下的载流量值。a. 0. 6/1-8. 7/10KV b. 450/750Vc. 300 / 500V d. 300 /300VMeasured cable current. carrying capacity under "a"environment is not less than the current-carrying ca-pacity value under work conditions of correspondingtype and specifications of common cable.2.导体长期允许工作温度按不同产品品种可分为：Allowed work temperature of cable for a long period isdivided into the following according to different kinds ofproducts:7.电缆的其它电性能及物理一机械性能均高于相应的普通电缆。70℃.90℃.105℃3.短路时（58）导体高允许温度为不超过160℃和250℃Other electric nature and physical. mechaníc nature ofcable are all higher than corresponding common cable.四、型号及规格 Type and Specifications1.电缆型号如表1中所列均为各品种之代表）For cable types. see Table 1(all listed in Table 1 are representatives of various kinds)表1Table额定电压型号Type名称使用范围Rated VoltageNameScope of Application聚氯乙烯纤维云母及氟塑料复合绝缘耐火电力电缆NH-VVPVC fiber. mica&fluoline plastic compound sheathed fire-proof power cable0.6/ IKVNH-VLV石油、化工、冶金、发电厂，输变电站、高层建筑、地铁、通讯站、核工、军工。交联聚乙烯或硅烷交联聚乙烯纤维云母复合绝缘耐火电力电缆NH-YJY8.7/ 10KV及以下航空、阵道、高科研、消防系统等。XL,PE or silane XL,PE fiber&miea compound insulated fire-NH-YJLVmPetroleum, chermical industry, metal-lungy, power plant, tranesrniésion sab-way, telecommnications station, nu-clear project, military, aviation, tun-nels, high scientific research, firecontrol, etc.proof power cableNH-KVV聚氢乙烯纤维云母复合绝缘耐火控制电缆NH-KVVPVC fiber&mica compound insulated fire-proof control cable聚氯乙烯纤维云母复合绝缘耐火控制（软）电缆PVC fiber&mica compound insulated fire-proof control softcableNH-KVVR450/750V聚氯乙烯纤维云母复合绝缘屏蔽耐火控制软电缆NH--KVVPPVC fiber&mica compound insulated,metal sereened fire-proof control soft cableNH-KVVRP石油、化工，冶金，高层建筑，科研等动力照明装置及电气、仪器仪表要求防火的场合。聚氯乙烯纤维云母复合绝缘耐火电线NH-BV450 /750VPVC fiber&mica compound insulated fire-proof wirePetroleum, chemical industry, metal-hangy, high rises, scientiflic researchand other power and illuminating in-stallation, electric irstrument and me-ters requiring fire-piroof.聚氯乙烯纤维云母复合绝缘耐火软电线NH-BVR450/750VPVC fiber&mica compound insulated fire—proof soft wire聚氧乙烯纤维云母复合绝缘耐火电缆NH-BVV300 / 500VPVC fiber&mica compound fire-proof cable